•   
  •   
  •   

Ownership Is that Road Salt, or Something Else?

18:12  16 february  2018
18:12  16 february  2018 Source:   autotrader.ca

Sticky road salt solutions make cleaning your car more important

  Sticky road salt solutions make cleaning your car more important De-icing fluids contain ingredients that can stick to your car and damage mechanicals and parts over timeCome winter, your municipality used to keep you from slip sliding away by using a combination of rock salt and sand. It would be applied after the snow had started, to penetrate through the ice and provide traction. It was a less than ideal solution, for several reasons. Rock salt can literally blow off the road surface in wintry conditions, lessening its effectiveness. Waiting for accumulation meant road crews could be on the road at 2am and 4am and more, chasing conditions and requiring expensive multiple overtime shifts on shrinking budgets.

Covered Roadway in Winter Showing Tire Tread© autoTRADER.ca (Haney Louka) Covered Roadway in Winter Showing Tire Tread

If you live anywhere that gets nasty weather, you’re familiar with the trucks that lumber along the roads and dump whatever it takes to keep everything moving. Exactly what they’re dropping will depend on where you are, what the weather’s like, how much money your municipality has to spend, and what kind of trucks it owns.

Research

Research

Of course, you also have to think about what that stuff is doing to your vehicle. Here’s a rundown on what might be out on your roads.

Rock Salt

Plain rock salt, properly known as sodium chloride, is the great old grandpa of the snow-plow set. It’s cheap, it’s easy, and because it’s been around so long, virtually every municipality has equipment to spread it. It’s also just lying in wait and smirking until it gets its salty hands on your vehicle.

You’ve Gotten Stuck in the Snow, Now What?

  You’ve Gotten Stuck in the Snow, Now What? Well, now you’ve gone and done it: you’ve mucked things up badly, screwed up hard, and picked a whole bouquet of oopsie-daisies. You’ve become stuck, badly, in some snow and ice and slush.Video: Holiday concrete truck that will brighten up your night (provided by Autoblog) Your browser does not support this video require(["binding"], function (binding) { binding("wcVideoPlayer", "#video_player_386534e7-7512-40d3-b5b7-0eb2e1017d60").all(); }); Probably, you’re already late for work or a meeting or a date. Maybe, you’re not dressed for the occasion. Likely, you’re swearing.

Plain water freezes at 0°C. Salt lowers its freezing point, so it stays liquid instead of turning to ice when the thermometer drops below that. Salt needs to mix with the ice to be effective, and doesn’t do much if it’s just sitting on top of it. The streets can still be slippery if you’re the first one out after the salt truck has passed, because it’s the traffic driving over the salt that works it into the ice so it can do its business.

Sodium chloride’s major drawback is that it’s an environmental nightmare. It kills vegetation and pollutes waterways, and it destroys concrete and rusts metal. If the roads in your area are salted, wash your vehicle frequently in winter, paying special attention to the undercarriage. Take it to the do-it-yourself, or use a pressure washer, and spray under the vehicle until the water runs clear.

I Have Determined The Correct Amount Of Horsepower

  I Have Determined The Correct Amount Of Horsepower There are often, sadly, engines that have too little horsepower. There are often, disconcertingly, engines with too much horsepower. Through extensive and vigorous testing as an Automotive Journalist, I have determined the correct amount of horsepower. The correct amount is, of course, 300 horsepower.Anything more than 300? An absurd, frankly dangerous amount. Anything less? Get outta here with your weak sauce.Allow me to present my case before you comment, with your takes that 73 and/or 90,000 horsepower is “actually” the correct amount of horsepower, which they are not.

a truck on a city street© Provided by autoTRADER.ca

Salt Brine

The name says it all: liquid mixed with sodium chloride, and sometimes other de-icers, sprayed on the roads with specialized trucks. It’s not applied to existing ice, but rather, it’s put down before bad weather is expected, and it dries and sticks to the road. When snow or freezing rain falls, that thin dried-brine layer prevents ice from sticking to the asphalt, making it easier for plows to scrape the surface clean.

Environmentally speaking, brine is better than rock salt, because less is required. It also stays where it’s put, at least initially. But it still washes onto the shoulders and into whatever green stuff grows alongside once the ice melts. When the weather warms up, that brine-salt coating gets moist and very sticky, and your tires will happily propel it into your vehicle’s nether regions. In addition to turning your sheet metal into Swiss cheese, it also attacks wiring, which can affect your ride’s electronics. Some jurisdictions add an anti-corrosion solution, but don’t count on that to save you. As with rock salt, keep your vehicle’s underside clean throughout the winter months.

Your Corner Wrench: Take care with spring cleaning your car

  Your Corner Wrench: Take care with spring cleaning your car Hosing your car down or using cleaning chemicals may do more harm than goodWater and electronics (or pretty much anything electrical) do not mix. This might seem simple enough, but it happens. Few vehicle owners ever take into consideration what might be hidden beneath floor carpeting before they take a home steam cleaner to some stubborn salt stains. Most automakers run a variety of electrical harnesses and even some computers here and if you absolutely have to use moisture to clean it, use a very small amount.

Pre-Wetted Salt

a truck driving down a street© Provided by autoTRADER.ca

A combination of the previous two, this is rock salt sprayed with salt brine before it’s deployed. Rock salt bounces when it hits the pavement and often vaults right into the ditch, where it doesn’t do anybody any good. Pre-wetted salt is more likely to stay where it lands. The brine also speeds up the process of turning ice into salty water. This salt-and-brine combination is just as bad for the environment, and for your vehicle, as either one alone.

Beet Juice

Beet what? Yes, some municipalities are spreading vegetables on the roads. It’s the liquid left over when sugar beets are refined into sweetener. It’s mixed with salt and used like brine, but it’s a little better on the environmental side.

It’s similar to salt-and-water brine, but beet juice is stickier – it’s basically thin molasses – and it does an even better job of gluing the thin salt layer to the asphalt, making it more effective. It can also lower the freezing point to −32°C for better cold-weather protection. It’s more expensive than mixing salt with water, but it can reduce salt use by up to 60 percent. Some municipalities save it for areas with extra environmental concerns, such as roads that run through wetlands or cross rivers.

Here's What Those Weird Black Tubes In The Road Are For

  Here's What Those Weird Black Tubes In The Road Are For I’ve been thinking about tubes. Specifically, the weird black tubes that you often find stretched across a roadway. What are those tubes for? What are they tracking? How do they work? The official name for these ominous road snakes is just “pneumatic road tube,” and if you guessed that they probably just take a traffic count, you are mostly correct. But they also do so much more!Here’s a good description of the actual operation of the tube setup from the U.S. Department of Transportation:Pneumatic road tube sensors send a burst of air pressure along a rubber tube when a vehicle’s tires pass over the tube.

Beet juice isn’t the only foodstuff doing double duty on the roads. Depending on what’s available from local suppliers, some municipalities may use cheese brine, pickle juice, or spent grain mash from beer or liquor production. As far as your vehicle goes, consider beet juice to be an even stickier method of adhering salt to your sheet metal.

De-Icers

a group of people walking down the street© Provided by autoTRADER.ca

Rock salt isn’t the only thing that’ll turn ice to water. There are other de-icers that work even better, including magnesium chloride, potassium chloride, and urea. Rock salt gives up starting around −12°C, but calcium chloride keeps working down to about −30°C, and creates heat when it gets damp so it works even faster. Meanwhile, potassium acetate can do its job when the temperature dips as low as −60°C, and it’s biodegradable to boot.

But you never get something for nothing. Calcium chloride is about twice the price of rock salt, while potassium acetate costs about eight times as much.

The price of alternatives limits their use, and they’re spread mostly on smaller areas such as sidewalks. However, some municipalities mix them with larger volumes of rock salt for roads. If they end up on your vehicle, they tend to break the metal’s molecules apart, and they can potentially do more damage than sodium chloride alone.

How One City Is Using Optical Illusions to Prevent Traffic Accidents

  How One City Is Using Optical Illusions to Prevent Traffic Accidents How Fake Speed Bumps Can Reduce Speeding If anything, you’d think optical illusions on the road would be dangerous. But in London, transportation operators are using optical illusions as part of a crusade to make the roads safer--and it’s working! (What’s not safe: putting your feet on the dashboard.

Sand

a car covered in snow© Provided by autoTRADER.ca

At the coldest temperatures, nothing’s going to turn ice to liquid, and that’s when sand comes in. Rather than melting the ice, it sits on top and helps give drivers some traction. It doesn’t present much of an environmental issue – other than the fact that, worldwide, we’re starting to face a global shortage of sand – although it has to be swept up or shovelled away once winter has passed.

It’s reserved for Canada’s most frigid areas, since it would have to be reapplied too often in regions that regularly thaw and freeze. The resulting accumulation could clog the storm drains. Other than its abrasive effect when it’s tossed by the wind or other vehicles driving alongside, it’s not a hazard for your fenders.

Pickled Sand

Sand has a tendency to clump if it gets moist, which can gum up the sanding trucks. To avoid clogging, it’s sometimes mixed with salt, at five to 10 percent of its volume, and the mixture is known as pickled sand. While it’s far less of a problem than a dump of 100 percent rock salt – again – wash your vehicle regularly if your municipality uses it.

Extra Protection

a car parked on the side of a building© Provided by autoTRADER.ca

All dry de-icers are hygroscopic, meaning they absorb moisture, since they need at least a bit of liquid to start the process. That’s bad news for your vehicle, since even a dry layer of salt dust will eventually draw humidity when the temperature warms up, and that salty liquid is hungry for metal. Invest in undercoating or oil spray before winter, and make sure to get all the nooks and crannies: inside the doors, behind the tail lights, and inside the tailgate if you drive a truck. Wax your vehicle often, and touch up stone chips as soon as they happen. Let salt and de-icers do their job on the roads, not on your ride.

How to Wash the Winter Salt Off Your Car .
A detailed guide on getting off all that corrosive grime.Video: A paint job you can peel off (provided by Autoblog) Your browser does not support this video require(["binding"], function (binding) { binding("wcVideoPlayer", "#video_player_f82f09a1-0576-44b2-88e2-3fe81432af39").

—   Share news in the SOC. Networks

Topical videos:

This is interesting!